1984 Chevrolet G30 Recalls

NHTSA Recall 07E088000

Component: EQUIPMENT

Recall date: 2007-10-24

Defect Summary

CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND HP8 OIL FILTERS NOT BEARING A DATE CODE IN THIS RANGE ARE NOT AFFECTED BY THIS RECALL. THE GASKET OF THE OIL FILTER BECOMES MORE PLIABLE UNDER HIGH TEMPERATURES AND PRESSURES.

Safety Risk

THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.

Remedy

HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.

NHTSA Recall 84V133000

Component: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP

Recall date: 1984-10-16

Defect Summary

DUE TO A MANUFACTURING PROBLEM WITH THE FUEL TANK FILLER PIPE, THE FUEL CAP MAY IMPROPERLY SEAL THE END OF THE FILLER PIPE. THIS FAILS TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 301, "FUEL SYSTEM INTEGRITY." IN THE EVENT OF A COLLISION, AN IMPROPERLY SEALED FILLER PIPE COULD ALLOW FUEL SPILLAGE.

Safety Risk

Remedy

THE DEALER WILL INSPECT AND REPLACE FUEL CAPS ON ALL AFFECTED VEHICLES WITHOUT CHARGE.

NHTSA Recall 84V095000

Component: EQUIPMENT:APPLIANCE:AIR CONDITIONER

Recall date: 1984-08-20

Defect Summary

PLASTIC PLUG LOCATED ON TOP OF THE FRONT AIR CONDITIONER WAS NOT REMOVED DURING ASSEMBLY. THIS DEFECT DISRUPTS NORMAL OPERATION OF EVAPORATOR BLOWER HOUSING.

Safety Risk

Remedy

REAR A/C SYSTEM BLOWER WILL BE INSPECTED FOR DAMAGE SUCH AS MELTING OR BURNING. IF NO DAMAGE IS DETECTED, THE RESISTOR WILL BE REPLACED AND ANY REMAINING PIECES WILL BE REMOVED. IF DAMAGE IS DETECTED, THE RESISTOR AND THE A/C EVAPORATOR INLET CASE WILL BE REPLACED.